2022 Honda Pilot parts and specs

What changed for the 2022 Honda Pilot

• 2022Final year of the 3rd generation; Special Edition trim on 18-in wheels

Known problems with the 2022 Honda Pilot

3 of the 5 issues we track for the 2016–2022 generation are documented against the 2022 model year, and 2 carry a recall or service bulletin.

• Rear subframe corrosion, 2026 recall

  majorNHTSA 26V-367

  Honda recalled roughly 880,000 vehicles in June 2026, including 2016–2022 Pilot, along with related Ridgeline, Passport, and Acura MDX models, because the rear subframe can corrode at the points where the rear suspension mounts to it, allowing the rear suspension to fail. Honda estimates only about 1% of affected vehicles actually have the defect, concentrated in road-salt states. Dealers inspect the subframe and either install a reinforcement kit or repair/replace the subframe as needed, free of charge. Run your VIN even if the vehicle looks and drives fine, corrosion isn't always visible from underneath.

  Typical cost: Free under recall

• Fuel pump failures, two separate recall campaigns

  majorNHTSA 23V-858 (2015–2020 production); NHTSA 20V-314, expanded 21V-215 (2020–2022 Pilot/Passport)

  Two unrelated fuel-pump defects were recalled on this generation. First, a Denso-supplied low-pressure fuel pump whose impeller can swell and cause stalling or hard starts, recalled under NHTSA 20V-314 and expanded under 21V-215 to cover 2020–2022 Pilot and Passport. Second, a broader in-tank fuel pump defect (module may fail and cause the engine to stall while driving) covered 2015–2020 Pilot production under NHTSA 23V-858, with owner notification letters mailed as late as September 2024, if you own an affected model check your VIN, as many cars in this recall wave remain unrepaired years after the campaign opened. Both remedies are a free fuel pump/module replacement at any Honda dealer.

  Typical cost: Free under recall

• A/C compressor and condenser failures ('black death' oil contamination)

  moderate

  A/C compressor failures are a widely reported and expensive complaint on this generation, owners describe warm air from the vents, sometimes preceded by a failing compressor clutch or relay, and sometimes progressing to a catastrophic compressor failure that contaminates the entire A/C system with metal debris and black sludge ('black death'), requiring a full system flush plus compressor, condenser, and drier replacement. Checking the compressor clutch relay first is a cheap diagnostic step before condemning the compressor.

  Typical cost: $400–$700 for an isolated condenser; $2,000–$4,700 for a full system replacement after a contaminated compressor failure

Full detail, costs and sources on the Honda Pilot problems and years to avoid guide.